Subaru wrx dohc turbo full service repair manual 2002. Reading : Subaru Wrx Dohc Turbo Full Service Repair Manual 2002 2019-03-17

Subaru wrx dohc turbo full service repair manual 2002 Rating: 5,6/10 1310 reviews

Subaru Impreza STi 2002 Service Manual

subaru wrx dohc turbo full service repair manual 2002

Doing so may damage the cylinder. . A E C 16 Remove the oil control valve assembly, intake camshaft cap, and camshaft. Each System Check} in Main Menu. Ensure sure double lines C on the intake cam-shaft and exhaust camshaft sprockets are aligned. Be careful not to burn yourself during measure- ment. Compression 350 rpm and fully open throttle : Standard; 951 — 1,147 kPa 9.

Next

SUBARU WRX DOHC TURBO Workshop Service Repair Manual

subaru wrx dohc turbo full service repair manual 2002

Each System Check} in Main Menu. Tightening torque: 39 N·m 4. Idle Air Control Solenoid Valve 12. Install a new 9 Install the extension case. This ten-dency becomes more evident as engine temperature rises.

Next

SUBARU IMPREZA 2002 SERVICE MANUAL Pdf Download.

subaru wrx dohc turbo full service repair manual 2002

Variable Valve Timing Solenoid Valve. Make sure to support the correct positions. Belt tension A replaced: 7 — 9 mm 0. G6M0095 2 Remove the console cover. Front kgf lb 970 2,138 1,030 2,271 Rear kgf lb 920 2,028 920 2,028 Maximum permissible weight M. Tightening torque: 39 N·m 4.

Next

WRX & STI Factory Service Manuals

subaru wrx dohc turbo full service repair manual 2002

Replace the oil seal if the lips is deformed, hardened, dam- aged, worn or defective if any. Front kgf lb 760 1,676 785 1,731 815 1,797 875 1,929 Rear kgf lb 535 1,179 530 1,168 550 1,213 575 1,268 Total kgf lb 1,295 2,855 1,315 2,899 1,365 3,009 1,450 3,197 Maximum permissible axle weight M. Its chassis has been successful in rallying compared to its contenders. Gears are difficult to intermesh. When engine speed is reduced slowly from higher speed, needle stops temporarily when it is lowering or becomes steady above normal position. It will be the complete procedure for overhauling of the engine itself when you go through all steps in the process.

Next

Reading : Subaru Wrx Dohc Turbo Full Service Repair Manual 2002

subaru wrx dohc turbo full service repair manual 2002

Front kgf lb 805 1,775 825 1,819 Rear kgf lb 585 1,290 585 1,290 Total kgf lb 1,390 3,065 1,410 3,109 Maximum permissible Front kgf lb 970 2,138 970 2,138 axle weight M. Using the same procedures described previously, then measure the valve clearances again. Select the fork rod which applies to the calculated value from following equation. Front kgf lb 900 1,984 900 1,984 900 1,984 900 1,984 900 1,984 900 1,984 900 1,984 900 1,984 Rear kgf lb 910 2,006 910 2,006 910 2,006 910 2,006 910 2,006 910 2,006 910 2,006 910 2,006 Maximum permissible weight M. Weak or broken valve springs 6. The clearance can be checked by measuring the outside diameter of valve stem and the inside diameter of valve guide with outside and inside mi- crometers respectively.

Next

Reading : Subaru Wrx Dohc Turbo Full Service Repair Manual 2002

subaru wrx dohc turbo full service repair manual 2002

Front kgf lb 735 1,621 755 1,665 750 1,654 770 1,698 Rear kgf lb 520 1,146 520 1,146 520 1,146 520 1,146 Total kgf lb 1,255 2,767 1,275 2,811 1,270 2,800 1,290 2,844 Maximum permissible axle weight M. Tightening torque: Lock nut A ; 22. Tightening torque: 34 N·m 3. Replace the belt tension pulley if faulty. . Tightening torque: Engine mounting; 35 N·m 3.

Next

Subaru Impreza STi 2002 Service Manual

subaru wrx dohc turbo full service repair manual 2002

Thus, do not mix two or more brands. Fuel Delivery, Return and Evaporation Lines 33. If not block is shifted to neutral position. Front Differential Assembly 12 Wrap vinyl tape around the spline part of axle shaft. Thickness mm in 6 Inspect all valves for clearance again at this stage. If the valve clearance is not correct, repeat the procedure over again from the first step.

Next

SUBARU IMPREZA 2002 SERVICE MANUAL Pdf Download.

subaru wrx dohc turbo full service repair manual 2002

Tightening torque: Engine mounting; 35 N·m 3. Q, Will this Manual expire in 12 months or will I have to pay a renewal fee? Tightening torque: 44 N·m 4. H2M1954 S2M1927 17 Separate the clutch release fork from release 5 Remove the power steering tank from the bracket by pulling it upward. Select the fork rod which applies to the calculated value from following equation. Front kgf lb 830 1,830 895 1,973 Rear kgf lb 560 1,235 575 1,268 Total kgf lb 1,390 3,065 1,470 3,241 Maximum permissible axle weight M. Right-side cam-shafts are held so that their cams do not push valves down. Camshaft 10 Remove the right-hand belt cover No.

Next